Repair service 3C0905861 XX J764 ELV ECU VW Passat 3C CC

You are buying a repair service steering column lock
ELV control unit module J764 with 24 months warranty

Installed in:
VW Passat 3C 2005 - 2015
Passat CC 2009 - 2017

The following ELV control units J764 can be repaired:
3C0905861A 3C0905861B 3C0905861C
3C0905861D 3C0905861E 3C0905861F
3C0905861G 3C0905861H 3C0905861J


Possible errors in the system:
- Ignition can no longer be switched on
- Steering wheel remains locked, yellow steering wheel control lamp lights up
- The vehicle no longer starts.
- The engine starts and then turns off again (WFS active)
- 02811 - Control unit for steering column lock (ELV) J764, 014 - defective
- 02815 - Supply voltage for locking motor, 002 lower limit value not reached
- 02817 - ELV enable line from steering wheel electronics, 002 lower limit value not reached
- 02818 - ELV enable line for electronic ignition lock short circuit to plus or ground
- 02823 - Locking condition for ELV not met.
- 02835 - Steering column lock communication J764, 004 - no signal
- 02861 - Electronic steering column lock J764, 014 - defective
- 02861 - Electronic steering column lock J764, 008 - implausible signal
- J764 - Electronic steering column lock ELV ECU internally defective


Solution:
Apply the brake or switch on the light via gateway ECU 19 the ELV module J764
Address word 25 and delete the error memory!
After deleting the error memory, everything works again for a short time!
Cause: electrical components in ECU for steering column lock J764 defective.


Our service:
Installation of 2 microswitches + 2x 20A power relays + servomotor for steering column lock
  into the control unit! Including function test on the test bench.
Original spare parts are used!

We install all parts professionally and professionally for you!

Repair service procedure:

1. You buy this service & pay via PayPal or bank transfer.
2. You send only your defective ELV module control unit J764 in a plastic housing
without a steering column with a vehicle key to our address.
The vehicle key is required for the function test on the test bench.
3. We will repair your ELV module J764 on the same or next day.
4. Then we send the repaired ELV module J764
back to you with DHL service.

We need the following components